Open Access
ARTICLE
Chicken Eggshell as an Innovative Bioflocculant in Harvesting Biofloc for Aquaculture Wastewater Treatment
Hajjar Hartini Wan Jusoh1, Nor Azman Kasan2,*, Hidayah Manan2, Nurfarahana Mohd Nasir1,3, Fareza Hanis Mohd Yunos1, Sofiah Hamzah1, Ahmad Jusoh1,2,*
1
Faculty of Ocean Engineering Technology and Informatics, Universiti Malaysia Terengganu, Kuala Nerus, Terengganu, 21030,
Malaysia
2
Institute of Tropical Aquaculture and Fisheries (AKUATROP), Universiti Malaysia Terengganu, Kuala Nerus, Terengganu, 21030,
Malaysia
3
Faculty of Engineering, Universiti Putra Malaysia, UPM Serdang, Selangor Darul Ehsan, 43400, Malaysia
* Corresponding Authors: Nor Azman Kasan. Email: ; Ahmad Jusoh. Email:
Journal of Renewable Materials 2023, 11(5), 2321-2332. https://doi.org/10.32604/jrm.2023.026086
Received 15 August 2022; Accepted 17 November 2022; Issue published 13 February 2023
Abstract
Implementation of biofloc technology (BFT) system in aquaculture industry shows high productivity, low feed
conversion ratio, and an optimum culture environment. This study was divided into two phases. The first phase
involved maintaining the water quality using the optimum carbon-to-nitrogen ratio by manipulating pH in culture water. The second phase examined the performance of harvesting biofloc (remaining phytoplankton and suspended solids in the system) using chicken eggshell powder (CESP). This study showed that pH 7 to 8 were the
best biofloc performance with high removal percentage of ammonia (>99%) with a remaining ammonia concentration of 0.016 mg L
−1 and 0.018 mg L
−1
, respectively. The second phase of this study was performed to determine the optimal formulation and conditions of using CESP as a bio-flocculant in harvesting excess biofloc. The
use of eggshell showed a higher harvesting efficiency of more than 80% under the following treatment conditions:
0.25 g L
−1 of eggshell dosage; with rapid and slow mixing rates of 150 and 30 rpm, respectively; 30 min of settling
time; settling velocity of 0.39 mm s
−1 and pH of 6 to 7. Therefore, the results indicated that biofloc would be the
best green technology approach for sustainable aquaculture wastewater and the CESP is an organic matrix that
environmental-friendly bio-coagulant for biofloc harvesting.
Graphical Abstract
Keywords
Cite This Article
Hartini, H., Kasan, N. A., Manan, H., Nasir, N. M., Hanis, F. et al. (2023). Chicken Eggshell as an Innovative Bioflocculant in Harvesting Biofloc for Aquaculture Wastewater Treatment.
Journal of Renewable Materials, 11(5), 2321–2332.